ADLINK Technology cPCI-6860A Series Manual de usuario

Advance Technologies; Automate the World.Manual Rev. 2.00Revision Date: October 27, 2006Part No: 50-17024-1000PXIS-3320PXIS-3320/1000W15-Slot 6U PX

2Introduction1.1 Features X Supports both 6U PXI and CompactPCI modulesX PXI specifications Rev. 2.2-compliantX Supports one system slot and 14 PXI/Co

Introduction 31.2 Unpacking ChecklistBefore unpacking, check the shipping carton for any damage. Ifthe shipping carton and/or contents are damaged, i

4Introduction

Chassis Overview 52 Chassis OverviewThis section illustrates the mechanical dimensions of the PXIS-3320 and PXIS-3320/1000W chassis, identifies the b

6 Chassis OverviewFigure 2-2: PXIS-3320/1000W front viewPower switchAlarm reset buttonLEDsFan tray coverFan tray coverPower supply modulesFan tray cov

Chassis Overview 72.2 Right ViewFigure 2-3: PXIS-3320 and PXIS/1000W right view2.3 Top ViewFigure 2-4: PXIS-3320 and PXIS/1000W top viewHandle

8 Chassis Overview2.4 Rear ViewFigure 2-5: PXIS-3320 and PXIS-3320/1000W rear viewCircuit breakerPower connector

Chassis Overview 92.5 Backplane overviewThe PXIS-3320 chassis comes with a 6U, 15-slot PXI backplanethat supports one PXI system controller and 14 PX

10 Chassis OverviewStar Trigger SlotSlot 2 is designated as the Star Trigger (ST) slot. This slot featuresa dedicated trigger line between itself and

Chassis Overview 1110 MHz Reference ClockThe backplane supplies every peripheral slot with a 10 MHz sys-tem clock signal (PXI_CLK10). An independent

Copyright 2006 ADLINK TECHNOLOGY INC.All Rights Reserved.DisclaimerThe information in this document is subject to change without priornotice in order

12 Chassis Overview

Installation 133 InstallationThe chapter describes the procedures on how to install the systemcontroller to the PXIS-3320 chassis. It also provides i

14 Installation3.2 Installing the Chassis and Starting UpFollow the steps to power on the chassis.1. For rackmount or bench-top installation, provide

Installation 159. Press the power switch. The amber LED and greenLEDs on the upper right corner of the front panel light up.The chassis fans also sta

16 Installation3.3 Monitoring the SystemLight Emitting Diodes (LEDs) on the front panel tell you the powerstatus, chassis temperature, and fan operati

Installation 173.5 Grounding the ChassisThe backplane’s mounting holes may be grounded in two ways.First, the mounting holes labeled as GND with circ

18 Installation3.7 Changing the Fans The PXIS-3320 chassis has ten 80 mm x 80 mm x 25 mm fans.These fans are installed in two decks of fan trays. Five

Troubleshooting and Preventive Maintenance 194 Troubleshooting and PreventiveMaintenance4.1 Troubleshooting for Power Failure of PXIS-3320When the PX

20 Troubleshooting and Preventive Maintenance4.2 CleaningIt is recommended that you clean the interior and exterior of thePXIS-3320 chassis regularly.

Specifications 21A SpecificationsA.1 GeneralComplies with PXI specifications and accepts modules compliantwith CompactPCI, PICMG 2.0 specifications.A

Getting service from ADLINKCustomer satisfaction is our top priority. Contact us should yourequire any service or assistance.ADLINK TECHNOLOGY INC.Web

22 SpecificationsA.3 System MonitoringSystem LEDsBuzzer/AlarmA.4 Cooling SystemFront-access hot-swappable fan trays for air intake and ventilationX Ty

Specifications 23A.5 PhysicalX Number of slots: 15 (one system slot, 14 peripheral slots)X Dimensions: 484 mm x 295 mm x 398 mm (L x W x H) with-out

24 Specifications

Backplane Drawing and Pin Assignments 25B Backplane Drawing and Pin AssignmentsB.1 Backplane LayoutThe following figures show the front and rear view

26 Backplane Drawing and Pin Assignments.Figure B-2: CBX-6015 rear view

Backplane Drawing and Pin Assignments 27B.2 Backplane CBX-6015 ConnectorsPin AssignmentsPXI Connectors Pin AssignmentsSystem Slot (Slot #1) P1 Pin As

28 Backplane Drawing and Pin AssignmentsSystem Slot (Slot #1) P2 Pin AssignmentPin Z A B C D E F22 GND PXI_BRSVA22 PXI_BRSVB22 PXI_BRSVC22 PXI_BRSVD22

Backplane Drawing and Pin Assignments 29Star Trigger Slot (Slot #2) P1 Pin AssignmentPin Z A B C D E F25 GND +5V REQ64# ENUM# +3.3V +5V GND24 GND AD[

30 Backplane Drawing and Pin AssignmentsStar Trigger Slot (Slot #2) P2 Pin AssignmentPin Z A B C D E F22 GND PXI_BRSVA22 PXI_BRSVB22 PXI_BRSVC22 PXI_B

Backplane Drawing and Pin Assignments 31General Peripheral Slot (Slot #3~#15) P1 Pin AssignmentPin Z A B C D E F25 GND +5V REQ64# ENUM# +3.3V +5V GND

32 Backplane Drawing and Pin AssignmentsGeneral Peripheral Slot (Slot #3~#15) P2 Pin AssignmentPin Z A B C D E F22 GND PXI_BRSVA22 PXI_BRSVB22 PXI_BRS

Backplane Drawing and Pin Assignments 33B.3 Bus Segments and Interrupt RoutingsBus Slot # IDSELREQ# /GNT#PCICLKPXI P1Pin A3PXI P1Pin B3PXI P1Pin C3PX

34 Backplane Drawing and Pin AssignmentsB.4 Bus Segments and Interrupt RoutingsPhysical Slot Number PXI_STAR (P2-D17)Slot 2(Star Trigger Slot) PXI_STA

Backplane Drawing and Pin Assignments 35B.5 Miscellaneous Connectors Pin AssignmentsCN1, CN7, CN8, CN9: ATX-like DC Power input connectorsNOTE Pin #8

36 Backplane Drawing and Pin AssignmentsJ6 INH#: DC power inhibit signalJ8 RST#: System reset signalJ9 FAL#: Power supply fail inputJ5: Connector for

Backplane Drawing and Pin Assignments 37CN5: SMB (System Management Bus) connector NOTE The SMB is connected to the P2 of the system slot.JP1: 10 MHz

38 Backplane Drawing and Pin Assignments

Important Safety Instructions 39Important Safety InstructionsRead and follow all instructions marked on the product and in thedocumentation before op

40 Important Safety InstructionsX Openings in the chassis are provided for ventilation. Do notblock or cover these openings. Make sure there is adequa

Warranty Policy 41Warranty PolicyThank you for choosing ADLINK. To understand your rights andenjoy all the after-sales services we offer, please read

Table of Contents iTable of ContentsList of Tables... iiiList of Figures ...

42 Warranty Policy3. Our repair service is not covered by ADLINK's guaranteein the following situations:X Damage caused by not following instruct

ii Table of ContentsA Specifications... 21A.1 General ...

List of Tables iiiList of TablesTable 3-1: LED indications ... 15Table 4-1: Troubleshooting Po

vList of FiguresList of FiguresFigure 2-1: PXIS-3320 front view .... 5Figure 2-2: PXIS-3320/1000W front

Introduction 11 IntroductionThe ADLINK PXIS-3320 is a 19" 6U PXI chassis featuring onesystem slot and 14 PXI peripheral slots. The chassis is co